内蒙古神州硅业年产3000吨多晶硅项目工业仪表安装施工方案含DCS系统.doc
《内蒙古神州硅业年产3000吨多晶硅项目工业仪表安装施工方案含DCS系统.doc》由会员分享,可在线阅读,更多相关《内蒙古神州硅业年产3000吨多晶硅项目工业仪表安装施工方案含DCS系统.doc(37页珍藏版)》请在文库网上搜索。
1、Parents generally value the first class, mainly to see whether the students can accept the tutor, so the first class is more important. It is best to understand the students learning situation first, to communicate well with their parents in advance, to make adequate preparations for the students st
2、udy habits, learning habits, good or bad learning, and what knowledge they have mastered, whether they are willing to study, whether they are willing to learn, or whether they are willing to study, and whether they are temperamental and so on. Only in this way can the target be targeted. If the foun
3、dation is relatively poor, it is necessary to review the old knowledge, accompanied by the corresponding exercises to make consolidation; learn better,仪表施工方案目 录:第一章 工程概述第二章 编制依据第三章 仪表分部分项工程的划分第四章 施工人员准备第五章 施工程序第六章 施工方法第七章 质量保证体系和质量保证措施第八章 施工安全保证措施第九章 形象进度计划第十章 施工机具、标准仪表计划you can properly deepen the
4、difficulty. However, it is suggested that we should not focus only on exercises and not on knowledge points. In fact, communicating with students is better than communicating with students. The first and most important thing is to have patience, probably speaking many times the exercises, the conten
5、t, they still can not remember, at this time must not be angry, calm, take a variety of methods to teach, find suitable for his study habits or way of thinking. After all, the tutor is not a teacher in the classroom, do not have to pull so far away from the students. Third, oneself to teach the cont
6、ent of knowledge, so that they can explain brilliantly. And students of this age are easy to despise teachers who can not answer the question. On the basis of understanding the students, make a plan to cooperate with the exercises. As for the cost, be sure to communicate well with the parents before
7、 the lecture, better not in front of the students. To stick to your own principles, let me advise you not to lower the price, but to talk more about it. Dont lose face, its your earned income from work.总承包方:中国成达工程公司 编制单位:中国化学工程第十四建设有限公司项目名称:内蒙古神州硅业3000吨/年多晶硅项目 文件名称:仪表施工方案第一章 工程概述一、概况:内蒙古神州硅业3000吨/年多
8、晶硅项目,位于内蒙古自治区呼和浩特市金桥开发区,工程合同范围包括:110KV总变、车间变电所、主控楼、还原、氢化、氯化氢合成、三氯氢硅合成、粗馏、CDI、空分制氮、脱盐水、综合泵房等单位工程,主要工作范围包括非标设备钢结构制作、设备、工艺管道、电气、仪表、防腐保温等各分部工程。本工程自控仪表中控室设在综合楼,控制系统采用DCS系统进行控制,对全厂的温度、压力、流量、液位、分析仪表进行监视和调节。现场设过渡接线箱,现场仪表通过接线箱和多芯屏蔽电缆与主控室DCS机柜相连,尤其是对于热电偶MV信号采用了多路温度采集系统通信电缆RS485连接,大大降低了用补偿导线把热电偶的冷端 ( 自由端 ) 延伸到
9、控制室内的仪表端子上的缺点,更为业主节省了建设成本。现场多数为防爆场所,现场仪表和相应的接线箱也都设置了相应的防爆等级,另现场设置了有毒气体和可燃气体检测报警器,更加保证了现场人员和设备的安全,现场仪表的选型为国内外比较先进的仪器仪表,技术先进、性能可靠、兼容性强、自动化水平高。 二、主要实物量:第二章 编制依据2.1成达设计院提供的内蒙神州硅业3000吨/年多晶硅项目设计图纸。2.2 工业自动化仪表施工及验收规范 GBJ50093-2002。2.3 国家电气标准规范汇编。2.4 石油建设工程质量检验评定标准,自动化仪表安装工程(SY4031-93)。2.5自控安装标准图册。2.6 化工建设工
10、程交工文件技术规定。2.7 企业标准 质量手册 质量控制手册 其它有关企业标准2.8 我公司编制的国家级工法总体分散综合控制TDCS-3000工法。第三章 仪表分部分项工程的划分以各工号为仪表分部工程分部工程分 项 工 程仪表安装分部工程1、 仪表操作台安装2、 桥架安装3、 穿线管敷设4、 电缆敷设5、 导压管线敷设6、 气源管线敷设7、 压力仪表安装8、 液位仪表安装9、 流量仪表安装10、 调节阀安装11、 检测仪表回路调校12、 调节仪表回路调校13、 报警联锁调试第四章 施工人员准备4.1 施工任务划分主要分成以下几个作业系统(区)。DCS集散控制系统、控制室、现场仪表、桥架电缆。各
11、作业系统(区)配备相应施工人员,同时依据各系统进展情况,随时进行调整。4.2 施工人员选择 配备仪表施工队队长一名、高级工程师一名、工程师一名。 施工班长由现任仪表班长担任。 施工人员中仪表工选择技术素质较高,有施工经验的人员。 DCS集散控制系统、以及仪表调试主要由仪表高级工程师、工程师负责。4.3 施工人员的培训4.3.1 施工前设计人员需向施工管理人员进行技术交底,施工技术人员向施工班组进行技术交底。尤其是DCS的安装及调试要求进行交底,内容包括:图纸要求、规范标准、施工步骤、技术措施和检验方法等。4.3.2 组织施工人员熟悉图纸及有关资料规程规范,专门针对性训练和技术培训(如PLC系统
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 内蒙古 神州 年产 3000 多晶 项目 工业 仪表 安装 施工 方案 DCS 系统